自上料一體車操作規則_公司新聞_新聞資訊_自動攪拌一體車_自動攪拌一體機_多功能攪拌車價格-山東山汽工程機械(集團)有限公司

站內搜索

新聞資訊

公司新聞行業動態

熱點

自動上料平口攪拌機多種方量可供選擇

2022-12-23

混凝土自動上料攪拌車的功能有哪些？

2022-12-19

混凝土自動拌料車移動式可自行走戶外施工

2022-12-16

自上料攪拌車企業這么多，買車的時候應該看哪方面？

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自上料一體車操作規則

所屬分類：公司新聞發布時間：2021-07-22 來源：http://www.sumtokenco.com/ 瀏覽量：0

攪拌車一體車是將水泥，砂子骨料和水混合并將其混合成混凝土混合物的機器。它主要由一個攪拌桶，一個供水/卸載機構，一個供水系統，一個原動機，一個傳動機構，一個框架和一個支撐裝置組成。只有安全合理的設備操作才能改善設備的性能，因此以下編輯人員將向您介紹設備的安全操作程序。

The mixer truck is a machine that mixes cement, sand, aggregate and water to form a concrete mixture. It mainly consists of a mixing drum, a water supply / unloading mechanism, a water supply system, a prime mover, a transmission mechanism, a frame and a supporting device. Only safe and reasonable equipment operation can improve the performance of the equipment, so the following editors will introduce the safe operation procedures of the equipment to you.

1.駕駛之前，您需要仔細檢查車輛的狀況，以確保其可以安全行駛。

1. Before driving, you need to carefully check the condition of the vehicle to ensure that it can drive safely.

2.將攪拌車一體車在室外時，必須在倒入攪拌桶之前進行加水和排水，以確?；炷恋馁|量。

2. When the mixer truck is outdoors, water must be added and drained before pouring into the mixing bucket to ensure the quality of concrete.

3.在運輸混凝土時，請牢固放置傾斜的槽，同時使混凝土溢流，以免因松動而晃動，在駕駛時傷害行人或影響其他車輛的正常行駛以及土壤污染。

3. When transporting the concrete, please firmly place the inclined slot, and at the same time make the concrete overflow, so as to avoid shaking due to loosening, hurting pedestrians or affecting the normal driving of other vehicles and soil pollution when driving.

4.從上料攪拌機運輸混凝土的時間不能超過攪拌站指定的時間。在混凝土運輸過程中，請勿長時間停止攪拌桶，以防止混凝土分離。駕駛員應始終注意具體情況，如果發現任何異常，應通知中央控制室，并尋求。

4. The time of transporting concrete from the loading mixer shall not exceed the time specified by the mixing plant. In the process of concrete transportation, do not stop the mixing bucket for a long time to prevent concrete separation. The driver should always pay attention to the specific situation. If any abnormality is found, the driver should inform the central control room and seek treatment.

5.在汽車中安裝混凝土時，現場停機時間不得超過1小時。如果發生加班，現場負責人必須及時做出回應。

5. When installing concrete in the car, the on-site downtime shall not exceed 1 hour. If overtime occurs, the person in charge of the site must respond in a timely manner.

6.從裝載攪拌機中不抽水時，從混凝土到燃料箱的時間不應超過2小時，并且應在2小時或更長時間后排出。雨中溫度較低時，請勿超過2.5小時。

6. When water is not pumped from the loading mixer, the time from the concrete to the fuel tank shall not exceed 2 hours, and it shall be discharged after 2 hours or more. When the temperature is low in the rain, do not exceed 2.5 hours.

7.噴射混凝土之前，必須在攪拌前以10-12rpm的轉速旋轉攪拌桶1分鐘。

7. Before shotcreting, the mixing drum must be rotated at 10-12rpm for 1 minute before mixing.

8.現在不再提供攪拌器，應沖洗進水口，出料斗和出水槽以排干水，以閥體上的污垢和殘留的混凝土。保持車輛衛生。

8. The mixer is no longer provided. The water inlet, outlet hopper and outlet tank should be flushed to drain the water to remove the dirt and residual concrete on the valve body. Keep the vehicle clean.

機械設備在操作和使用過程中需要某些的操作流程。您在駕駛時需要了解攪拌車一體車的操作程序?；谝陨现R，我希望您正確地操作和使用它。

Mechanical equipment needs some safe operation process in the process of operation and use. You need to know the safe operation procedure of mixer truck when driving. Based on the above knowledge, I hope you can operate and use it correctly.

上一頁：全自動攪拌一體車結構組成情況下一頁：自動攪拌一體車的除塵設備很重要!

熱門產品 / HOT PRODUCT