操作自上料攪拌車需要注意的要點有哪些？_公司新聞_新聞資訊_自動攪拌一體車_自動攪拌一體機

站內搜索

新聞資訊

公司新聞行業動態

熱點

自動上料平口攪拌機多種方量可供選擇

2022-12-23

混凝土自動上料攪拌車的功能有哪些？

2022-12-19

混凝土自動拌料車移動式可自行走戶外施工

2022-12-16

自上料攪拌車企業這么多，買車的時候應該看哪方面？

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

操作自上料攪拌車需要注意的要點有哪些？

所屬分類：公司新聞發布時間：2022-03-09 來源：http://www.sumtokenco.com/ 瀏覽量：0

自上料攪拌車放料時，水箱的水要盡量保持滿狀態。冬天應該排干凈水，防止凍裂。下面跟著小編一起學習下自上料攪拌車的操作要點。

When discharging from the loading mixer, the water tank shall be kept as full as possible. Water should be drained in winter to prevent frost cracking. Now follow Xiaobian to learn the operation points of self loading mixer.

1、攪拌車在水泵作業時，制止空轉，接連運用時不要超越15分鐘。

1. When the mixer truck is working with the water pump, stop idling and do not exceed 15 minutes in continuous operation.

2、攪拌車放料前先把出料斗溜槽打濕。放料時把車盡量停在平地上放料。

2. Wet the chute of the discharge hopper before discharging. When discharging, park the vehicle on the flat ground as far as possible.

3、卸料不要粗心和放料工打好聯系。放料時盡量自己看著，免得放料工亂操作放料操作桿，每次罐子正反轉中間位子時盡量停一下，維護減速機，托輪等。與放料工打好聯系，卸料時也不要睡的太熟，萬一工人鬧情緒，把你車子放到工地不轉罐子，形成悶罐就麻煩了。

3. Don't be careless in unloading and make good contact with the discharging worker. Try to watch by yourself when discharging, so as to avoid the discharging operator operating the discharging lever disorderly. Try to stop every time the tank is in the middle of the reverse direction, and maintain the reducer, supporting wheel, etc. Make good contact with the discharging worker and don't sleep too well during unloading. In case the worker is in a mood, put your car on the construction site and don't turn the can, it will be troublesome to form a stuffy can.

4、攪拌車水箱的水量要經常保持裝滿，以備急用，冬天停機后，應將水箱、水泵、水管、拌和筒內的水放凈，并停放在向陽、不積水的地方，避免凍壞機械。

4. In winter, the mixer shall be kept in the water tank, which shall not be filled with cold water, and the water pump shall be kept in the place where the mixer is shut down and ready for use. In addition, the water tank shall be kept in the place where the mixer is shut down in winter.

5、卸料前讓拌和罐全速作業一兩分鐘。讓混凝土充沛拌和，必要時可以加一些水，讓混凝土拌和得更均勻，也方便卸料。

5. Allow the mixing tank to operate at full speed for one or two minutes before unloading. Let the concrete be fully mixed. If necessary, add some water to make the concrete mix more evenly and facilitate unloading.

6、攪拌車作業結束，應把拌和筒內部和車身清洗干凈，不能使剩下的混凝土留在筒內。

6. After the operation of the mixer truck is completed, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.

7、拌和罐一定要細心地沖刷干凈。洗罐子時一定要細心的沖刷干凈，并把水反復的正反轉兩次，再放出來，然后一趟時把水箱的水悉數放進罐子，再回到站加水完全清洗罐子。

7. The mixing tank must be washed carefully. When washing the jar, be sure to wash it carefully, and repeat the positive and negative rotation of the water twice, and then release it. Then put all the water in the water tank into the jar, and then return to the station to add water to completely clean the jar.

8、攪拌車在冬天應及時裝置保溫套，并運用防凍液對攪拌車加以維護，根據氣候改變更換燃油標號，確保機械的正常運用。

8. In winter, the mixing truck shall be equipped with insulation sleeve in time, and the mixing truck shall be maintained with antifreeze. The fuel grade shall be changed according to the climate change to ensure the normal operation of the machinery.

9、在檢查、修補攪拌車液壓傳動部分時，應使發動機和液壓泵在沒有壓力的情況下進行。

9. When inspecting and repairing the hydraulic transmission part of the mixer truck, the engine and hydraulic pump shall be operated without pressure.

10、在調整混凝土自動上料攪拌車各部間隙、行程、壓力時，應由專職檢查員檢查贊同；更換機件時，一定要由部長或主管司理簽字，否則出現問題后追究有關人員職責。

10. When adjusting the clearance, stroke and pressure of each part of the automatic concrete feeding mixer, it shall be checked and approved by the full-time inspector; When replacing the machine parts, it must be signed by the minister or the competent manager, otherwise the responsibilities of relevant personnel will be investigated in case of problems.

以上就是為大家介紹的有關全自動上料攪拌車的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.shanqijituan.com/

The above is a detailed introduction to the automatic feeding mixer truck. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.shanqijituan.com/

上一頁：經常打死水泥攪拌車方向盤很傷車！下一頁：多功能的攪拌車能在哪些路況下施工？

熱門產品 / HOT PRODUCT